 |
Sicherheitsmitteilung 011102
Datum: 25.11.2001
Hersteller: Icarus Canopies
Herstellerbulletin: PSB #20011025
Betrifft: Icarus Crossfire Hauptschirme
Problem: In Amerika und New Zeeland wurden Schirme hergestellt mit fehlerhafter Leinentrimmung. Das Benutzen von den Frontrisertoggles (Schlaufen an den vorderen Haupttragegurte) kann zu einer großen Instabilität vom Schirm führen. Dieses kann zum Zuklappen vom Schirm führen
Maßnamen: Alle Schirme, mit den Seriennummern von der Liste Annex 1, müssen nach Prozedur wie umschrieben in #CF0110 modifiziert werden. Nach der Modifikation muss es auf dem Warninglabel vermerkt werden. Wenn diese Modifikation noch nicht ausgeführt wurde bleiben die Beschränkungen wie umschrieben in Sicherheitsmitteilung SM 010901 in Kraft.
Schirme mit den Seriennummern von der Liste Annex 2 müssen nach Prozedur wie umschrieben in #CF0102 modifiziert werden, Crossfire mit Spectra leinen müssen mit Vectran Leinen neu beleint werden
Herstelleranweisungen betreffend Prozedur #CF0110 und #CF0102 können beim Hersteller beantragt werden.
Status: Verpflichtend
Ausnahme: In Europa hergestellte Crossfire sind nicht betroffen. Schirme die nach 01.februar 2001 neu beleint oder nachgetrimmt wurden sind nicht betroffen.
Wirksamkeitsdatum: Sofort
Beilage: Product Service Bulletin #20011025
|
|
|
Product Service Bulletin
#20011025
Date of Notice: October 25, 2001
Effective: Immediately
Applicability: Serial Numbers Attached
Requirement: Line-trim adjustment
Compliance: Mandatory
Compliance Date: November 30, 2001
Note: This Service Bulletin supersedes Safety Bulletins #20010914 & #20011004.
Background:
Safety bulletin #20010914 was released on 14 September 2001 following the identification of some Crossfire’s that experienced buffeting and/or instability while using front riser control inputs. Users were advised to refrain from performing front riser control inputs below 1000ft AGL.
Safety Bulletin #20011004 was released on October 04 expanding on our knowledge of the situation resulting from testing to that date. Additionally a further warning was issued to Crossfire users requesting that those users with limited experience, who may not possess the necessary knowledge to determine whether or not their canopy may be affected, should refrain from using their canopy pending the conclusion of our testing.
Resulting from subsequent testing we have been able to stabilize all affected Crossfire’s by performing a minor line-trim modification to the canopy. Further action may be taken at a later date however we feel it prudent to act quickly and decisively to stabilize any canopies which may be affected and to allow Crossfire users to return to flying their canopy without flight restrictions.
Required Action:
(Annex 1) Canopies with serial numbers attached as annex 1 require line trim modification specification #CF0110. This modification must be performed before 30 November 2001.
Upon completion of the line trim modification the canopy warning label must be placarded by the rigger who performed the modification by using a permanent marker & writing on the warning label as follows:
COMPLIES WITH SERVICE BULLETIN #20011025; MM/DD/YY; NAME; SIGNATURE; RIGGER CERTIFICATE NUMBER.
Note: Canopies remain subject to the flight restrictions as stated in bulletin #20010914 and #20011004 until such time as this modification is performed. Upon completion of the modification these canopies are no longer subject to any flight restrictions. It is recommended that these modifications are performed immediately. Canopies not modified before 30 November 2001 will be considered grounded at that stage.
Canopies with serial numbers not listed on Annex 1 or Annex 2 are not subject to this bulletin.
(Annex 2) Canopies with serial numbers attached as annex 2 require modification to trim specification #CF0102 before 30 November 2001. Note: Canopies in annex 2 that have been re-lined or re-trimmed since 01 February 2001 will have been fitted with trim specification #CF0102 at that time and will not require any further trim modification. Contact Icarus Canopies for details and to confirm whether your canopy requires this trim update.
Note: It is not necessary to Placard these canopies.
Performing the Trim Modification:
Icarus Canopies will perform the trim modification at no charge should you wish to return your canopy to our facility. Please contact Icarus prior to sending your canopy to attain a reference number. We will also advise an estimated time frame and investigate options to minimize any disruption to your jumping.
Should you wish to expedite this process, local master riggers are able to perform this trim change. Riggers can contact Icarus Canopies to request the necessary instructions and specifications to perform this modification. Additionally, should you not know of a rigger able to perform this modification and wish to have it performed locally, attached is a list of rigging lofts able to perform this modification with bartac equipment comparable to factory specifications. The trim change should take approximately 45 minutes to 1 hour and should be no more than the cost of a reserve re-pack.
Replacing Spectra Line with Vectran:
Due to the superior trim qualities of Vectran, Crossfire’s with Spectra line require a line-set replacement to Vectran before 30 November 2001. Contact Icarus Canopies for details.
Additional Information:
USA
Contact: Simon Mundell
Icarus Canopies
1627 US 1, Sebastian,
FL 32958, USA
PH (561) 581-8131
Fax (561) 581-8132
Email
simon@icaruscanopies.com
www.icaruscanopies.com Europe
Contact: Sascha Arndt
Icarus Canopies
P.I. El Ramassar - c/ Vallés, s/n O8520 Les Franqueses - SPAIN
Ph. (34) 938 496 432
Fax (34) 938 497 971
Email
sascha@icaruscanopies.com
www.icaruscanopies.com
Annex One:
Canopies requiring re-trim specification #CF0110
8132 96612820 96612911 96612974 96613087
8138 96612821 96612912 96612975 96613088
8139 96612822 96612914 96612976 96613089
8148 96612823 96612919 96612977 96613091
8160 96612835 96612924 96612978 96613092
8178 96612836 96612926 96612979 96613093
8186 96612848 96612927 96612980 96613094
8244 96612851 96612928 96612981 96613095
8251 96612852 96612929 96612982 96613096
8259 96612854 96612931 96612983 96613097
8432 96612855 96612932 96612994 96613098
8433 96612859 96612933 96612995 96613099
8434 96612860 96612937 96612997 96613100
8435 96612861 96612938 96612998 96613101
8436 96612862 96612939 96613008 96613102
8438 96612865 96612941 96613012 96613103
92912345 96612866 96612943 96613013 96613104
94112350 96612871 96612944 96613014 96613105
94812367 96612872 96612945 96613015 96613106
96612340 96612873 96612946 96613016 96613107
96612790 96612874 96612947 96613019 96613110
96612801 96612875 96612948 96613020 96613111
96612802 96612876 96612949 96613028 96613112
96612803 96612877 96612950 96613031 96613113
96612804 96612878 96612951 96613032 96613114
96612805 96612879 96612952 96613033 96613116
96612806 96612880 96612953 96613034 96613118
96612807 96612881 96612954 96613042 96613123
96612808 96612882 96612955 96613043 96613124
96612809 96612883 96612960 96613044 96613125
96612810 96612896 96612961 96613045 96613126
96612811 96612897 96612965 96613046 96613127
96612812 96612898 96612966 96613047 96613128
96612813 96612899 96612967 96613048 96613129
96612814 96612900 96612968 96613049 96613130
96612815 96612904 96612969 96613050 96613131
96612816 96612905 96612970 96613051 96613132
96612817 96612908 96612971 96613054 96613136
96612818 96612909 96612972 96613068 96613137
96612819 96612910 96612973 96613085 96613138
96613139 96613196 96613255 96613332
96613140 96613197 96613257 96613333
96613141 96613198 96613258 96613334
96613142 96613199 96613259 96613335
96613143 96613200 96613260 96613337
96613144 96613201 96613261 96613345
96613145 96613202 96613263 96613346
96613146 96613203 96613264 96613347
96613147 96613204 96613265 96712347
96613148 96613205 96613267 96712357
96613149 96613206 96613269 96712364
96613150 96613215 96613270 96812349
96613151 96613221 96613271 96812356
96613152 96613222 96613272 96912348
96613153 96613223 96613273 96912355
96613154 96613224 96613275 96912358
96613155 96613225 96613276 96912360
96613156 96613226 96613277 96912362
96613157 96613227 96613278 96912363
96613158 96613228 96613280 96912365
96613159 96613229 96613282 96912367
96613165 96613230 96613283 96912368
96613166 96613231 96613284
96613167 96613232 96613285
96613168 96613233 96613286
96613169 96613234 96613306
96613170 96613235 96613317
96613171 96613236 96613318
96613176 96613238 96613319
96613177 96613239 96613321
96613178 96613243 96613322
96613183 96613244 96613323
96613184 96613245 96613324
96613185 96613247 96613325
96613186 96613248 96613326
96613187 96613249 96613327
96613188 96613250 96613328
96613189 96613251 96613329
96613194 96613252 96613330
96613195 96613253 96613331
Annex Two:
Canopies requiring re-trim specification #CF0102. Contact Icarus Canopies for details.
50112559 50312630 96212806
50112562 50312648 96212809
50112574 50312654 96312732
50112580 50312657 96312738
50112586 50312666 96312741
50112601 50312675 96312747
50112607 50312684 96312750
50112613 50312705 96312753
50112619 50312717 96312756
50112622 50312729 96312759
50112646 96112739 96312762
50112667 96112742 96312765
50112676 96112745 96312768
50112679 96112748 96312777
50112685 96112751 96312786
50112694 96112754 96312789
50112703 96112763 96312795
50112718 96112766 96312798
50112727 96112769
50212560 96112781
50212572 96112784
50212575 96112787
50212617 96112793
50212623 96112796
50212659 96112799
50212674 96212737
50212677 96212740
50212689 96212743
50212701 96212746
50212707 96212749
50212722 96212752
50312561 96212755
50312570 96212770
50312576 96212776
50312579 96212785
50312600 96212791
50312615 96212794
50312618 96212797
50312621 96212800
50312624 96212803
|
|
